Water pooling under the fuel cap

Discussion in 'Mechanics Garage' started by Diziet-sma, Jun 16, 2020.

Tags:
  1. Diziet-sma

    Diziet-sma New Member

    Country:
    United Kingdom
    Joined:
    Jun 16, 2020
    Messages:
    3
    Likes Received:
    0
    Trophy Points:
    1
    Hi everyone. Hope someone may be able to help me with a bit of an issue. Yesterday I found a lot of water under the fuel cap after washing my bike. 1998 VFR800 fi-w. 5th gen. I've previously had to drain the fuel tank as it had water in and the bike stopped running.

    There a small hole, (see photo) which I assume is a drain, to take away any overspill, condensation or leaks. Is this right? There was a lot of water where that hole is around the outside of the fuel filler hole so I guess that hole or the pipe is blocked. I'm thinking this caused my previous issue too.

    Any idea where the hole and pipe from this runs so I can give it a clean out?

    If it's not a drain, should I look at replacing the filler cap as it obviously lets water through the ring into that depression which eventually finds it way into the fuel tank. should there ba gasket or seal around the ring to stop leaks?

    Thanks for any help any of you can provide.
     

    Attached Files:



    This site may contain affiliate links for which VFRworld may be compensated
    #1
  2. 34468 Randy

    34468 Randy Secret Insider

    Country:
    Canada
    Joined:
    Dec 18, 2007
    Messages:
    13,840
    Likes Received:
    1,619
    Trophy Points:
    158
    Location:
    Chilliwack, BC Canada
    Map
    I am not 100% sure but I think that drain hole is attached to a hose that comes out beneath the faring, one of two or three rubber tubes at the bottom. It is there for those who way overfill their tanks and the excess drains out to the ground. Maybe the rubber tube is missing from that drain which may allow water to get up inside there.
     


    This site may contain affiliate links for which VFRworld may be compensated
    #2
  3. raYzerman

    raYzerman Member

    Country:
    Canada
    Joined:
    Dec 3, 2019
    Messages:
    1,256
    Likes Received:
    476
    Trophy Points:
    113
    Location:
    Millgrove, ON
    Map
    Yes there is a drain hose, you'll have to find the bottom end and see it's not blocked... or blow air down it. 5th Gen has drain going along engine, out by clutch cover, round under/behind the rad, exits low on left side. Also a vent hose going on top of rear valve cover, down into frame and down at/near the front of the swingarm. Make sure neither are kinked....
    I replaced both mine with braided reinforced fuel line so they wouldn't kink... FYI, previous owner had kinked vent line and the fuel pump sucked hard enough to cave in the tank. Ouch.
    Drain line is a lesser deal, but you don't want it blocked.
     


    This site may contain affiliate links for which VFRworld may be compensated
    #3
  4. fink

    fink Member

    Country:
    United Kingdom
    Joined:
    Mar 6, 2013
    Messages:
    1,592
    Likes Received:
    458
    Trophy Points:
    113
    Location:
    Ardnamurchan Penninsula, Scotland
    Map
    Get a bit of strimmer line and run it down the overflow tube to clear it. Check also the breather tubes.
     


    This site may contain affiliate links for which VFRworld may be compensated
    #4
  5. squirrelman

    squirrelman Member

    Country:
    United States
    Joined:
    Jul 27, 2006
    Messages:
    10,187
    Likes Received:
    878
    Trophy Points:
    128
    Location:
    Buffalo, NY
    Map
    blo air in hole, clear flo
     


    This site may contain affiliate links for which VFRworld may be compensated
    #5
  6. Terry Smith

    Terry Smith Member

    Country:
    Kuwait
    Joined:
    Nov 18, 2013
    Messages:
    2,864
    Likes Received:
    713
    Trophy Points:
    128
    Location:
    Auckland, New Zealand
    Map
    upload_2020-6-17_14-7-36.png

    The overflow hose connects to the intake around the fuel cap area, on the underside of the tank.
     
    Last edited: Jun 16, 2020


    This site may contain affiliate links for which VFRworld may be compensated
    #6
  7. Diziet-sma

    Diziet-sma New Member

    Country:
    United Kingdom
    Joined:
    Jun 16, 2020
    Messages:
    3
    Likes Received:
    0
    Trophy Points:
    1
    Tried that, nearly gave myself a brain aneurism. It's quite firmly blocked.
     


    This site may contain affiliate links for which VFRworld may be compensated
    #7
  8. Diziet-sma

    Diziet-sma New Member

    Country:
    United Kingdom
    Joined:
    Jun 16, 2020
    Messages:
    3
    Likes Received:
    0
    Trophy Points:
    1
    Hi everyone, just wanted to say thanks for all your replies. Due to all the info you gave me, I managed to figure out the overflow was blocked between the hole in the photo and where the drainage pipe attaches under the fuel tank. A bit of penetrating spray, a homemade plunger and a pipe cleaner got the fluid draining away, albeit slowly. Should be quick enough to stop me getting water in the petrol tank again though.

    Thanks for all your help, it's appreciated.
     


    This site may contain affiliate links for which VFRworld may be compensated
    #8
Related Topics

Share This Page